首頁 >> 産品展示 >> 工程機械重工裝備運輸車輛零部件組件動態疲勞試驗機系統 >> 30kN.m工程機械車輛刹車制動壓力扭矩試驗機 Construction Machinery Vehicles Brake Moment Tester
30kN.m工程機械車輛刹車制動壓力扭矩試驗機
Construction Machinery Vehicles Brake Moment Tester
功能參數：
→30kN.m工程機械車輛刹車制動壓力扭矩試驗機，評估測試制動器連續運轉時，制動氣壓力變化對制動力矩的影響。制動力矩變化對制動氣壓力的影響。溫度變化對制動器性能的影響。
→去除制動器襯片襯塊和制動鼓盤摩擦表面的油脂、塗料等異物，將制動器樣品按實車狀態安裝到HRJ疲勞試驗機上，按連接螺栓螺母規定擰緊力矩緊固。進行制動器磨合試驗和制動器疲勞強度試驗。檢查鼓式制動器支承部位銷孔變形，制動蹄鐵變形及破損，摩擦襯片的移位，制動底板的變形，安裝部位變形及松動。檢查盤式制動器制動襯塊插入部位變形，制動鉗的變形，制動襯塊變形及破損，安裝部位變形及松動。
→汽車制動器疲勞性能試驗溫度測量裝置，測量記錄制動器溫度，制動襯片塊溫度測量，制動鼓盤停止轉動後15s內溫度變化測量。制動液溫度變化測量，制動試驗動作解除後間隔1min制動液溫度變化測量。
→20bar/s氣壓控制，制動鼓減速度制動力矩3.5m/s2或5.9m/s2，制動周期5s±0.5s，制動時間少于1.5s，制動鼓盤轉角大于15°，制動次數5000次/50000次。載波頻率信號調理。
→繪制制動鼓盤轉角-時間曲線，制動力矩-時間曲線，制動鼓盤前進方向轉動時間曲線，制動鼓盤返回時間曲線，制動時間曲線，制動力矩穩定時間曲線，制動鼓盤空轉時間曲線，制動器溫度控制曲線。
引用標准、文獻文件：
Construction Machinery Vehicles Brake Moment Tester；Automobile Service Brake Fatigue Strength Bench Tester；Wheel Hub Rotating Moment Vibration Acceleration Fatigue Tester；Sealing Ring High Low Temperature Compressive Torsion Fatigue Tester；hrjtest；Caterpillar Band Sealing Ring Fatigue Durability Life Tester；Floating Seal Running Wear Leakage Performance Tester；Optical Cables Splice Torsion Bending Fatigue Tester；Air Suspension Air Spring High Low Temperature Fatigue Life Tester；Commercial Vehicles Cab Air Spring Fatigue Life Tester；High Speed Train Shock Absorber Fatigue Life Tester；Railway Vehicle Shock Absorber Fatigue Life Tester；Vertical Dampers Fatigue Life Tester；Cable clamp Rotary Bending Endurance Tester；hrjtest；Steering Drive Axle Gearbox Differential Assembly Tester；Outdoor Cabinets Mechanical Properties Tester；Air Spring Two Dimensional Stiffness Fatigue Tester；hrjtest；Screws Studs Bolt Torque Strength Tester；Preloading Structural Bolting Assemblies Tester；Rubber Elastic Pads Static Stiffness Tester；Butt Fusion Joints High speed Tensile-Impact Tester；Carbon Fiber High speed Strain Tensile Tester；Composite Insulator Core Stress Corrosion Tester；Polymer Matrix Composite Materials Tension Fatigue Tester；Rubber Plastic Polymer Materials Tensile Fatigue Tester；Sealant Tensile Compression Fatigue Tester；Components Tension Compression Bending Fatigue Tester；Aluminium Alloys Dynamic Fatigue Tester；Ten Brake Cable Tensile Tester；Pipe Fittings Torsion Fatigue Tester；Intervertebral Body Fusion Device Biomechanics Tester；
|
